They're just so cozy and homey and lovely. I can't get enough.
I went to Pinterest first and saw a lot of DIY grain sack pillow covers, but I didn't want to deal with finding the perfect linen fabric, then painting/printing/stamping anything on and I don't own a sewing machine.
After looking everywhere online, I wasn't loving the prices of the real deal. I was finding a lot of knock-offs but they just didn't look and feel like the real thing. I knew there had to be a way to make my own without a sewing machine.
Then I started searching for just the grain sacks and found several styles in many different conditions. They started at around $10 on the lower end, all the way up to $50+, depending on the type and condition. I noticed that the width on many of them were the same width of my pillows, and the length was just over double. I figured I'd have the perfect amount of material to make two covers.
I didn't mind a little wear and tear (it just adds to the character!) so I scored a nice vintage 19x42" Bemis sack on Etsy for $22 shipped.
It was perfect.
See where I'm going with this?
The design was right in the center which means it would be split, but I didn't mind the mostly plain pillows at all. If you wanted to center the design you could always pick up two grain sacks or find one with a design at the bottom.
To split it evenly I measured the center and drew a line...
Then I made my cut.
I didn't want the rough cuts showing, so I turned to the one and only Stitch Witchery:
For the first cover that was open on both ends, I had to stitch the bottom shut. I flipped the cover inside out, made sure it was lined up, and ran my stitch witchery across the bottom:
The top of this cover already had a nice hem from the factory, so I put it aside and addressed the rough cut on the second cover.
For this one I just had to fold the edges onto the inside all the way around the opening.
And that was that! I ended up with two perfect pillows with one open end...
I didn't want to close the seam permanently because then I could never wash the covers or swap them out down the road. I couldn't sew a zipper on either, so I thought about sewing buttons on it and almost went for it, but then I remembered these pillows I purchased from Ikea because I loved the little bows:
So I went through my leftover fabric stash and found some linen:
I cut it into six strips, then made little notches about 1" down with my Xacto knife:
Then I threaded each tie through and made knots:
And in less than one hour, I had my very own vintage grain sack pillows: